Purpose of the development: Wastewater treatment plants are designed for waste water containing suspended solids and oil. And modules are only suitable for indoor air temperature which eliminates freezing water in the tanks and pipes.

Recommended application field: Gas stations, car washes, surface and industrial construction.

Technical characteristic: Specifications: Designation module Rainbow-50-100 Rainbow Rainbow Rainbow-240-500 - Productivity, cubic m. / Hr no more than 2.5 6 10 20; - The effectiveness of nonchemical treatment to oils, greases, petroleum products,% not more than 99.9 99.9 99.9 99.9; - Purification of suspended substances,%, max 99.5 99.5 99.5 99.5; - Efficiency primeneiya reagents %, Max 99.98 99.98 99.98 99.98; - Total power, kW, not more than 5.59 7.62 7.62 18.68; - Dimensions of the pressure module flotation, mm, not more Length 2550 2530 2730 3310; width 1400 1900 2530 2400; Height 1620 2100 2120 2620; - Dimensions of the filter, mm, not more length vstoroen 1325 1325 1325; width 1300 1300 1300; Height 1280 1280 1280; - The number of filters 1 1 2 4; - The mass, m, not more Transportation 1.8 2.3 0.84 4.15; Operating 3.2 7.6 12.0 28.15.

The development stage readiness: Introduced in production

Description of the development:
()
Modules "Rainbow" are used in waste water treatment washing vehicles (creating water cycle), storm water off-site gas stations, garages, parking lots, tank farms and other similar composition drains. This technology can achieve concentrations of oil output of 0.05 mg / l. When you reset the treated water to the relief or any water fishery may use different disinfection systems. Automatic mode does not require the constant presence of an operator. In the installation "Rainbow" combined flotation and filtration purification. Skimmer extracts the bulk of pollution (95%). Filter provides deep dochistku effluent to the standards MPC (99.9%). Effect of pressure skimmer based on the ability of air to dissolve in water at elevated pressure. When you reset the air pressure of the solution is released in the form of tiny bubbles, which are surfacing, capture and bring to the surface of the particle contamination. The original design of the filter allows the use of different types of filter material (crushed clay, hardwood sawdust, charcoal, etc.). The exhaust filter media and flotoshlam can be used in the production of road surfaces, fuel for boilers used in other schemes for recycling. The seasonal operation (cleaning storm water) accommodation unit in an unheated space (eg, frame-type). To average uniform flow of wastewater before the module is installed, if necessary feeding capacity, including settling zone (sand trap). Volume and dimensions of the receiving vessel and its separate elements rasschityvyutsya regard to local conditions. In this capacity placed sensors, which, depending on the volume of wastewater and the mode of entry was on and off the installation. When the content of the original waste water oil over 300 mg / l of suspended solids, or more than 200 mg / l of appropriate use of primary sedimentation. Total suction lift pumps modules should not exceed 5 meters to collect and store the flotation sludge must install a special container (tank). For smaller modules (output up to 5 cubic meters. / Hour) it is appropriate to establish a mobile chip catcher.

Possibility of transfer abroad:
Licence's sale
Realization of finished commodity

Photo

Country Russia

For additional information turn to:
E-mail: gal@uintei.kiev.ua