Purpose of the development: Compact, hydro-, chemical-free iron removal plant is designed to clean water from underground sources of iron compounds at a concentration of 0.3 mg / l according to GOST 2874-82 "Drinking Water."

Recommended application field: Water after cleaning is used for drinking water consumers.

Technical characteristic: Plant capacity, cubic meters / day. - 100 to 100 000 Feed pressure to aerator installation, MPa - 0.40 Height of the top of the installation, m - 5.2-5.5

Advantages over analogues: -independent, floating hydro-flushing filter loading. -no additional capacity and pumps for washing the filter, there is no compressor to supply air to the water source, plant operation is practically reduced to monitoring mode of the pumps I and II recovery. -install customer supplied fully ready for use, with a filtrate tank is only required to be engaged with pipe feeding raw water pump and the second rise to a place of discharge wash water, water consumption for washing itself is 1.5% of daily production. -The ability to increase plant productivity by blocking. -low materials and high reliability of the equipment. -no secondary pollution of water through the use of non-corrosive plastic materials

The development stage readiness: Introduced in production

Description of the development:
()
In the plant cleans raw water from dissolved gases, such as hydrogen sulfide, carbon dioxide, methane, etc., removing turbidity and odor, nitrites and nitrates, suspended and colloidal particles, color reduction, carbonate hardness, the stabilization of the water. Feed water pump of I lift from artesian wells supplied to the aerator degassing, where there is intense oxidation of iron and oxygen in the air is the same air removal of dissolved gases. Treated water in this way then comes to hydro-filters with floating filter loading, where finally cleared of insoluble impurities. When dirty filter loading, the filter using gidrorobota independently switched mode samopromyvki, after which, as independently switched to the new filter cycle. Purified water is poured into the tank of clean water and then pump the second lift is supplied for consumption.

Certif №РОСС CZ.HО03.Н00579

corresponds technical description
Ready for implementation

Possibility of transfer abroad:
Licence's sale
Technological document's sale
Creation of joint enterprise
Realization of finished commodity

Photo

Country Belarus

For additional information turn to:
E-mail: gal@uintei.kiev.ua